|本期目录/Table of Contents|

[1]刘涛,谢文玉,温福,等.超声破乳-离心分离耦合工艺净化回收炼油厂乳化污油[J].石化技术与应用,2023,3:206-210.
　LIU Tao,XIE Wen-yu,WEN Fu,et al.Purification and recovery of emulsified waste oil by ultrasonic demulsification- centrifugal separation coupling process in refinery[J].Petrochemical technology & application,2023,3:206-210.
点击复制

超声破乳-离心分离耦合工艺净化回收炼油厂乳化污油(PDF)

《石化技术与应用》[ISSN:1009-0046/CN:62-1138/TQ]

期数:
2023年3期
页码:
206-210
栏目:
出版日期:
2023-05-10

文章信息/Info

Title:
Purification and recovery of emulsified waste oil by ultrasonic demulsification- centrifugal separation coupling process in refinery
文章编号:
1009-0045（2023）03-0206-05
作者:
刘涛1; 谢文玉1; 温福2; 何晓礼2; 朱越平1; 李长刚1
（1.广东石油化工学院 广东省石油化工污染过程与控制重点实验室，广东 茂名 525000；2.中国石化中科（广东）炼化有限公司，广东 湛江 524000）
Author(s):
LIU Tao1; XIE Wen-yu1; WEN Fu2; HE Xiao-li2; ZHU Yue-ping1; LI Chang-gang1
（1.Guangdong Provincial Key Laboratory of Petrochemical Pollution Process and Control，Guangdong University of Petrochemical Technology， Maoming 525000， China; 2. Zhongke（Guangdong） Refining & Chemical Co Ltd，SINOPEC，Zhanjiang 524000，China）
关键词:
炼油厂乳化污油; 超声破乳-离心分离耦合主体工艺; 脱水除油; 净化回收; 净化油
Keywords:
emulsified waste oil in the refinery; ultrasonic demulsification-centrifugal separation coupling main process; dehydration and oil removal; purification and recovery; purified oil
分类号:
X 742
DOI:
DOI：10.19909/j.cnki.ISSN1009-0045.2023.03.0206
文献标识码:
B
摘要:
针对中国石化中科（广东）炼化有限公司的炼厂乳化污油，当采用常规的长时间沉降切水回收后掺炼时，严重影响了常减压装置的安稳运行及其换热网络平衡。在实验基础上，设计出1套超声破乳-离心分离耦合主体工艺、处理量为400 L/h的乳化污油净化回收中试装置。运行结果表明：该装置连续稳定运行37 d，共处理炼厂高度乳化的清罐污油110 t，得到净化油72 t，乳化污油油料回收率为98.0%~98.4%；所得净化油的含水质量分数均小于0.1%，含盐质量浓度不超过15 mg/L，灰分低于0.04%，均达到净化油品质相应指标要求，净化油与蒸馏水的混合液无再次乳化现象发生，实现了乳化污油高品质回收。
Abstract:
The stable operation and the heat exchange network balance of the atmospheric and vacuum distillation unit were seriously affected，when using conventional long term sedimentation and cutting water recovery for the emulsified oil in the Zhongke（Guangdong） Refinery Plant， SINOPEC. Therefore，on the basis of the experiment，a pilot unit for purifying and recovering the emulsified dirty oil was worked out with the processing capacity of 400 L/h by applying a set of ultrasonic demulsification-centrifugal separation coupling main process. The results showed that this unit operated steadily for continuous 37 d，along with a total of 110 t highly emulsified cleaning tank waste oil of refinery was treated，and 72 t of purified oil was obtained，the recovery rate of the emulsified oil was 98.0%-98.4%. Moreover，not only the mass fraction of the water in the purified oil was less than 0.1%，the mass concentration of salt did not exceed 15 mg/L，and the ash content was less than 0.04%，i.e. the quality of the purified oil met the corresponding requirements，but also the high-quality recovery of the emulsified waste oil was achieved，due to the mixture of purified oil and distilled water would not emulsify again.

参考文献/References

［1］ 仝坤，宋启辉，刘光全. 老化油处理技术研究进展［J］.化工环保，2018，38（6）： 629-634. ［2］ 李海华，王大寿，葛永睿，等. 污油净化处理技术进展［J］.辽宁化工，2020，49（9）： 1124-1127.［3］ 葛卫学. 电脱法污油脱水室内实验研究［D］.青岛：中国石油大学（华东），2011.［4］ 王昌涵. 清罐污油多相分离处理技术研究［D］.北京：中国石油大学（北京），2019.［5］ 赵士乐. 聚醚类原油破乳剂的制备及性能［D］.济南：山东大学，2016.［6］ 田宫伟，陈颖，王亚林，等. 化学破乳机理及其研究进展［J］.硅酸盐通报，2018，37（1）： 155-159.［7］ Hou B， Jia R，Fu M， et al. Mechanism of wettability alteration of an oil-wet sandstone surface by a novel cationic gemini surfactant［J］. Energy Fuels，2019，33（5）： 4062-4069.［8］ Li K，Duan M，Wang H，et al． Investigation of adsorption dynamics of demulsifier on asphaltene by dual polarization interferometry measurement［J］. Colloid and Polymer Science，2015， 293（12）： 3555-3562．［9］ 薛浩浩. 联合站高效优化运行技术研究［D］.青岛：青岛科技大学，2018.［10］ Susumu N， Shunsuke K， Hideaki T. Quantitative approach to ultrasonic emulsion separation［J］. Ultrasonics Sonochemistry，2008，16（1）： 145-149.［11］ Xu X Z，Cao D，Liu J，et al. Research on ultrasound-assisted demulsification/dehydration for crude oil［J］. Ultrasonics Sonochemistry，2019，41（57）： 185-192.［12］ Wang Z， Gu S. Research on the static experiment of super heavy crude oil demulsification and dehydration using ultrasonic wave and audible sound wave at high temperatures［J］. Ultrasonics Sonochemistry，2018，40（1）： 1014-1020.［13］ Yi M，Huang J，Wang L. Research on crude oil demulsification using the combined method of ultrasound and chemical demulsifer［J］. Journal of Chemistry，2017 （3）： 1-7.［14］ 谢志勤，尹必跃，张淮浩. 高含渣污油的超声强化破乳机制［J］.油田化学，2017，34 （2）： 345-349. ［15］ Jaber T， Mahyar R， Akram S， et al. Wettability alteration by surface adsorption of asphaltene molecular in carbonate porous media［J］. Journal of Molecular Liquids，2022，345（1）： 118128.

备注/Memo

备注/Memo:
广东省茂名市科技计划基金资助项目（项目编号：2020 KJZX 037）
更新日期/Last Update: 2023-05-10